Chapter 946: Pick up the sledgehammer

"Check, you must thoroughly investigate, where did these stamping parts come from!" Director Zhang's expression was ashen. At this time, it was evening and it was time to get off work.
Since the equipment is still being debugged and the personnel are being trained, the factory's production capacity has not yet risen. This is the stage of small-batch trial assembly in the car factory. Therefore, there is no need to work all three shifts, and there is plenty of time to investigate.
The investigation is also very simple, because it is applied according to the strict quality management system from the Northern Heavy Truck Factory, so every part is labeled.
Soon, the reason was found. The stamping parts of this batch of vehicles were scrapped!
Yes, although the scrap symbol on the surface of the stamping parts has been erased, the label on the trolley and the signature of the quality inspector are clearly marked with the word scrap. Who knows, it was used by the workers in this workshop. I ignored it!
Director Wang's face was also ugly. He thought that if these parts were mixed in, no one would know. Who would have thought that in less than five minutes, they would be held accountable.
The quality inspector was not wrong. It was scrapped according to the scrapping standards. However, this batch of parts flowed into the next workshop process of the factory. Then, who is responsible?
"Xiao Liu, what's the matter?" Director Zhang asked Xiao Liu who was in charge of delivering the waste. He pushed out this batch of waste and dumped it on the waste pile. Who knows, it's now flowing back!
The person responsible for the investigation must of course be found from Xiao Liu.
Xiao Liu hesitated and didn't dare to speak. Looking at him, he knew that it must be the problem with him.
"We did not strictly follow our production procedures, leading to strict production accidents. Five body-in-white vehicles were scrapped and the factory lost tens of thousands of yuan. According to our requirements, we should be dismissed!" Director Zhang said sternly.
In this era, entering the factory means having an iron job. I don’t know how many people envy it. But now, Director Zhang is about to fire Xiao Liu, which means that Xiao Liu’s future Gone.
Director Wang finally couldn't help it, hitting the dog to see the owner. Isn't this showing that I'm not happy? Even if you are airborne, so what? You can’t make this factory so turbulent and panic, so that you can show that your new officials are in office.
"Lao Zhang, what are you doing? I think this batch of parts is a pity, so I brought them back. You see, haven't I restored them to the same level as before?" Director Wang stood up and said .
What's wrong with this? What's the big deal, didn't we do it like this before? I've been using a hammer for so many years, and now, you actually say that this is impossible? You have to use a machine to punch it out. If there is a slight defect, it will be scrapped. What a waste?
"Our country is poor. In the past, everyone used to beat and beat. What's the big deal?" Director Wang continued.
"Right." His words immediately drew a lot of echoes.
Hearing his words, Director Zhang couldn't help it anymore: "Quality, quality, quality, look at it, what slogan is on our factory?"
Quality is the life of the factory!
Zero tolerance for quality defects is required!
Change concepts, change styles, strictly manage management, and improve quality!
Almost all slogans carry these two words, which is quality!
Without quality, it is absolutely impossible!
Director Zhang continued: "Look, this body-in-white, although you beat it with a hammer, can the accuracy of hammering be compared with our stamping accuracy?"
As he said, he pulled the car door back and forth twice, and said, "Look, because the accuracy is not enough, so this sliding door is not flexible, there is always a jam, this car, sold to the user, the user found the door It’s not good, what should I say? We will definitely say that our quality is not good!"
Director Zhang took out a caliper again, watched the car door close, stretched in, and continued: "The gap between our car doors must not exceed 2 mm, but now? Under your knock, the gap at the door, A full 5mm! Most of our users are aimed at the countryside. On the dirt roads in the countryside, if this car is not tightly sealed, it will enter the soil, which will seriously affect our reputation. A village only buys one. Cars, the word of mouth spread, we are now in the market, we must not let our unqualified defective products leave the factory!"
Director Zhang's words, the people present still couldn't agree with it. What if the seal is not tight? The current car, which one is tightly sealed? Look at that old Jiefang, isn't it a car full of dust? Even when it was built before, there was only one half of the door. They can’t understand it, and it takes a long process to make them understand. After a few years, when the society thinks that the quality of the vans produced by the Haihe Automobile Plant is actually higher than the Santana, when the demand for vans exceeds demand, When the annual output of 300,000 vehicles was not enough, they understood that quality is the first vitality.
But now, we can only use compulsory methods to let them accept this idea, and at the same time, give them a deep impression!
Just when Director Zhang wanted to take the next step, He Ribala came.
Because of the new factory here, Heribala was worried. He had been sitting in the factory these days, and now, when he heard that there was a problem in production, he came over immediately.
When He Ribala came over, I saw Director Zhang was explaining the quality problem to the people present, but most of the people were actually disapproving.
"Bring me these defective products to the gate of the factory." Heribala said.
At this time, Heribala didn't say anything else. The people present didn't know what he meant, but with the quarrel here, more and more people watched.
When these defective products were pulled to the entrance of the factory, there was already a crowd of people with three floors inside and three floors outside.
Holding a big hammer in Heribala's hand, he slowly walked to the side of the defective product. When he saw his appearance, everyone present knew what was going to happen.
"I know that many of our masters think that some scraps can be used if they can be improvised, but now I want to solemnly tell everyone that as long as they are scrapped, they are scrapped. There is no improvised thing except for reprocessing. Say! You make do now, you fool the users now, that is, fooling the factory, fooling your own future! This kind of thing is never allowed to appear again in the factory!"
After speaking, Heribala picked up the sledgehammer. In the eyes of everyone, the sledgehammer in Heribala's hand slammed into the scrapped white body, and it also slammed into the hearts of these people.